Magnum MPG 3800 Návod k obsluze

PORTABLE GENERATORMPG 3800 • MPG 3800COPERATING/PARTS MANUAL

GROUND SOURCELOCATIONGROUNDING THE GENERATORPREVENTION OF OVERLOADExceeding wattage capacity can result in damage to the generator and to the connecte

WATTAGE CONSUMPTION OF EQUIPMENTDEVICE APPROXIMATE RUNNING WATTSAir Conditioner (12,000 BTU)** ...

ADDING ENGINE OIL1. Place the generator on a firm, level surface.2. Remove the oil fill cap/dipstick. Clean the areaaround the oil fill cap and wipe

STARTING THE ENGINE1. Unplug all electrical loads from the unit’s receptacles before starting the engine.2. Make sure the generator is on a firm, leve

STOPPING THE ENGINE2. Turn the idle control switch off.3. Switch the main circuit breaker to the off position.3. Let the unit run for 3-5 minutes with

• Check the engine oil level daily before starting engine.• DO NOT start the generator if the oil level is low! The normal operating level for the en

GROUND FAULT SENSING MODULEWARNINGTEST BEFORE EACH USESEE INSTRUCTIONSRESETRESETPOWERFAULTGFCI TESTING INSTRUCTIONS TEST BEFORE EACH USE!Normal operat

TOFRAMEITEM NO. PART NO. QTY DESCRIPTION1 26213 1 Panel, control - rear housing2 24986R 1 Panel, control3 65888 2 Receptacle, 120V/20A duplex-black4

18FRAME AND FUEL TANK ASSEMBLY118322145676822192928333291011133113301413101229281516172627192020232219272783435366252437

ITEM NO. PART NO. QTY DESCRIPTION1 26123 1 Valve, fuel tank2 26122 1 Gauge, fuel tank3 28495 1 Cap, fuel tank4 28494 1 Tank, fuel5 60393 4 Screw, .250

2INTRODUCTIONThis manual provides information and procedures to safely operate and maintain the portable generator. For yourown safety and protection

TOMUFFLERTO FRAMETOFRAMETOFRAMEENGINE AND GENERATOR ASSEMBLY201132123451029127333811151614121718198242625186192417232022211727191818302928313233343536

ITEM NO. PART NO. QTY DESCRIPTION1 60028 8 Screw, .312-18X1.000 hx hd2 60271 10 Washer, split lock .3123 61147 8 Nut, .312-18 U-clip G5 ZY long type4

22AC WIRING DIAGRAM1234(Y)(R)(B)(G)SEE DCPRINTWHT/BLKBLKCOMN/O1324LINELOADORN423COMMONS120 ONLY120/240XGWYGYWWXX867121011161415WXXGRN/YELWHTWHTWHTBLKY

DC WIRING DIAGRAM23ON/OFF SWITCHIDLE/RUN SWITCHIDLE/RUN MODULEGRNREDBLUORNIDLE/RUNSOLENOIDSHUTDOWNSOLENOIDCOILOIL LEVEL SWITCHOIL ALERT UNIT+ -CHARGE

REV: BPART NO: 2612602.04.09

TABLE OF CONTENTS3PageINTRODUCTION ...

Note: Notes contain additional information important to a procedure and will be found within the regulartext body of this manual.4OPERATING SAFETYBef

5ENGINE SAFETYInternal combustion engines present special hazards during operation and fueling! Failure to follow thesafety guidelines described belo

6Unit ID Tag215 Power Drive • Berlin, WI 549231-800-926-9768MODELSERIAL NUMBERMPG 5600000000120/240 120/24041.7/20.846.7/23.3kglbs. amb. temp.rpm hz p

7Read this manual carefully before attempting to use this generator. The potential for property damage, personalinjury or death exists if this equipm

FUEL TANK CAPFUEL LEVELGAUGEFUEL SHUTOFF VALVE(UNDER TANK)RECOILSTARTERCONTROL PANELENGINESTARTINGBATTERYBATTERY TRAY(OPTIONAL)ENGINEEXHAUSTWHEEL KIT(

GROUND FAULT SENSING MODULEWARNINGTEST BEFORE EACH USESEE INSTRUCTIONSRESETRESETPOWERFAULTABCDEFG HMPG 3800CONTROL PANEL COMPONENTSA. ENGINE START SWI